KIA RIO

since 2000 of release

Repair and car operation

Rio KIA
+ 1.1. Short acquaintance to the car
+ 2. Engines A3E, A5D
+ 3. Greasing system
+ 4. Cooling system
+ 5. Fuel system
+ 6. Ignition system
+ 7. Coupling
+ 8. Transmission
+ 9. Axes and power shafts
+ 10. Suspension bracket
+ 11. Wheels and tires
+ 12. Steering
+ 13. Brake system
+ 14. Body
+ 15. Air central air
- 16. Electric equipment
   16.1. Specifications
   16.2. Electric chains
   + 16.3. Generator
   - 16.4. Storage battery
      16.4.1. Normal charging of the storage battery
      16.4.2. The accelerated charging of the storage battery
      16.4.3. Check of the storage battery
      16.4.4. Check of level of electrolit
      16.4.5. Check of density of electrolit
      16.4.6. Check of tension of the storage battery
      16.4.7. Check of tension of the storage battery under loading
      16.4.8. Check of the current consumed from the storage battery at switched-off ignition
      16.4.9. Power failure check on connections of plugs of the storage battery
   16.5. Starter
   16.6. Check at a provorachivaniye of a cranked shaft not the heated-up engine
   16.7. Check of an electric chain of the traction relay
   16.8. Check of the traction relay
   16.9. Check of brushes and shchetkoderzhatel
   16.10. Check of coils of a stator
   16.11. Rotor check
   16.12. Removal and starter installation
   16.13. Starter repair
   16.14. Multipurpose switch
   16.15. Sound signal
   16.16. The block of safety locks and the relay, established in car salon
   16.17. Check of the relay of the activator of the lock of a door
   16.18. Check of the switch of adjustment of provision of an external rear-view mirror
   16.19. Check of the activator of provision of an external rear-view mirror
   16.20. Check of the engine of a window regulator
   16.21. Check of a heater of back glass
   16.22. Repair of a current-carrying strip of a heater
   16.23. Engine of a screen wiper of a windscreen
   16.24. Stekloomyvateli
   16.25. Adjustment of light of headlights
   16.26. Adjustment of light of fog lights
   16.27. Safety cushions (SRS)
   16.28. Precautionary labels
   16.29. Safety cushion of the driver and spiral wire
   16.30. Safety cushion check
   16.31. Check of a spiral wire (spring)
   16.32. Safety cushion of the forward passenger
   + 16.33. Electric circuits

16.4.3. Check of the storage battery

GENERAL INFORMATION

To failure of the storage battery can lead the following violations of service conditions:

– the plugs of the storage battery subjected to corrosion or unreliable connection of wires to battery plugs;

      – not tense or worn-out belt of a drive of the generator;
      – electric loading of the equipment of the car exceeds generator capacity. It can occur because of in addition established equipment;
      – slow movement of the car in the conditions of heavy traffic or operation of the engine idling with inclusion of a large number of consumers of electric energy;

– the electric chain leading to big consumption of a current is faulty;

– the electric chain of system of a charging is faulty;
– defect of the storage battery. Before check visually check the battery on absence of damages.

Prevention

If the storage battery has signs of freezing, leakages of the electrolit, the bared plates or low level of electrolit it is not recommended to charge the battery in connection with possibility of formation of an internal electric arch and the subsequent explosion therefore receiving injuries is possible.

The hydrogen allocated at a charging of the storage battery, gathers round the battery therefore using fire, is forbidden by the sparking devices opened by fire-dangerous light devices and smoking.

To work with the storage battery it is necessary in goggles. It is impossible to allow hits of drops of acid and the particles containing compounds of lead, in eyes, on skin or on clothes. At electrolit hit in eyes immediately wash out eyes pure water within several minutes. After that surely address to the doctor. At electrolit hit on skin or on clothes, immediately neutralize acid alkaline soap and wash out the corresponding place a large number at its finest.

Before installation of the storage battery on the car screw jams in battery banks